Improvement of Spawn, Compost and Cultivation Technique for Oyster Mushroom
Abstract：A series of works related with growing techniques for oyster mushroom were implemented to improve the efficiencies involved in spawn, compost, cultivation. To enhance the quality of sawdust spawn,fermentation technique was introduced to the spawn making. In an attempt to solve the problems of growing basic factor, the improvement of preparation of the substrate was carried out. Quality and productivity of Pleurotus ostreatus and P. sajor-caju were also assessed by a perforated polythene sheet covering technique.A method of spawn making procedures through the application of fermented sawdust for the purpose of avoiding contamination by undesirable fungi in the course of Pleurotus ostreatus mycelial growth was evaluated. Of three kinds of supplements, rice bran was the most effective to raise temperature up to 70?B℃. Mycelial activity and density were more considerably improved in the case of using fermented sawdust supplemented with rice bran than the case of non-fermented sawdust. Primordia of Pleurotus ostreatus were formed on fermented sawdust. The substrate of fermented sawdust showed potential to prevent the growth of Trichoderma sp. which caused a symptom on mushroom mycelium, whereas there was nothing to inhibit the growth of Trichoderma sp. during 30 days after inoculation in non-fermented sawdust. A composting technique was assessed to enhance efficiency in oyster mushroom substrate. Poplar sawdusts and by-product of winter mushroom added by 10% rice bran were composted outdoors at 20?B℃ to 28?B℃ for 12 days. The duration of composting shortened 3 days in fermented sawdust plot. The oyster mushroom substrate with fermented sawdusts promoted initial pins to produce a large lump of primordia. The highest yield was 742 g obtained from waste cotton substrate with fermented poplar sawdust, whereas the yield in control treatment 663 g. In addition, the substrate with by-product of winter mushroom was the most effective to composting. It was useful to apply fermented sawdust and recycled by-product to waste cotton associated with compost and sporophore production.Pleurotus spp. cultivation has been beset by several problems:contamination by undesirable microorganisms and pests, intensive labor requirements, and low crop quality owing to poor bed management. In an attempt to solve these problems, a perforated polythene sheet covering technique was assessed on crops of Pleurotus ostreatus and Pleurotus sajor-caju.At spawning, beds were covered with perforated transparent and black plastic sheet (0.03 mm thick; 10 cm diameter holes were spaced 10 cm apart giving 25 holes/m2). Additional spawn was inoculated to the bed surface through the holes. This technique made picking quicker with more efficient use of labor as mushrooms formed in bunches. Total yield of P. ostreatus increased by 5.7% to 10.8 kg/m2. The mean weight of a mushroom bunch from polythene sheet covered beds was 283 g (33 fruitingbodies) compared to 117 g (15 fruitingbodies) obtained using conventional growing methods. P. sajor-caju rapidly colonized the substrate and individual fruitingbodies formed into discrete bunches at the site of each hole. Total yield of mushrooms from both P. sajor-caju cultivation systems was 8 kg/m2. The mean of weight of mushroom bunches from a covered bed was 225 g (79 fruitingbodies) compared to single fruitingbodies (2.5 g) picked when using the conventional growing method. The evenness of the flush made picking quicker and reduced labor input by 52% (P. ostreatus ) and 64% (P. sajor-caju). Mycelia of ??Pleurotus spp. under vinyl remained healthy and white;whereas mycelium grown using conventional methods changed from white to yellow-brown during the cropping cycle. Very few fruitingbodies aborted after initiation using the covering technique.It is recommended that cultivation technique should be established on oyster mushroom based on improvement of spawn and compost.
Keywords：oyster mushroom; spawn; compost; cultivation technique
提高平菇產量的栽培新技術
Oh Se Jong Park Jeong Sik Shin Pyung Gyun Yoo Young Bok
摘 要：探討了一系列有關菇床的制備、栽培料的處理和發酵等提高平菇產量的栽培措施.為了提高鋸木屑的利用率,在制備菇床時引進了發酵技術;為了解決生長中一些基礎問題,改進了培養基質的處理方法.同時也評估了聚乙烯薄膜鉆孔覆蓋技術對兩種平菇(Pleurotus ostreatus和 P. sajor-caju)產量和品質的影響.在平菇菇床制備的過程中,為避免其它真菌菌絲的污染,使用了發酵后的鋸木屑法.結果表明,所用的3種添加物中,稻糠是促使培養基質升溫效率最高的添加物,可以升高到70?B℃.應用發酵鋸木屑添加稻糠生產的菌絲的活力和密度大大高于非發酵鋸木屑培養,并且其上可見平菇原基的形成.發酵鋸木屑在預防木霉的污染上顯示了一定的潛能,而非發酵鋸屑在接種后30 d內對木霉無能為力.研究了堆料(發酵)對平菇培養基物效率的提高能力.在白楊樹鋸木屑和冬蘑菇的栽培廢料中加入10%的米糠后,在20～28?B℃下室外堆放12 d.在發酵鋸木屑缽中發酵的持續時間縮短3 d.平菇在發酵基質中生長可以加快子實體原基的形成.用棉籽殼和發酵的白楊鋸木屑混合可以獲得最高的產量(742 g),而對照只有663 g.另外,用白楊鋸木屑與冬蘑菇培養廢料混合可以最有效提高發酵效率.在棉籽殼中添加發酵的鋸木屑和可循環的農副產品可以促進培養基質發酵和子實體形成.許多問題困擾著平菇的栽培:微生物和害蟲的污染,高強度的勞動力,因菇床管理不善而造成的栽培質量問題等.為了解決這些問題,鑿孔聚乙烯薄膜覆蓋技術被用來栽培Pleurotus ostreatus 和Pleurotus sajor-caju.菇床覆以打孔的、透明的、黑色的塑料膜(0.03 mm厚,孔直徑10 cm,孔間距10 cm以保證25 孔/ m2).菌種自孔接入菇床表面.此項技術因蘑菇成束形成而使采摘時效率更高,P. ostreatus的產量每平方米增加5.7% 到10.8 kg.聚乙烯薄膜覆蓋的菇床每束蘑菇的平均重量283 g(33子實體),而傳統的栽培方法為117g(15子實體).P. sajor-caju可以快速在基質上生長和定殖,并在孔口周圍成束長出子實體.P. sajor-caju栽培系統的總產量為8 kg/m2,薄膜覆蓋栽培平均每束菇的重量為225 g(79個子實體,而傳統的方法栽培的平均子實體重量為2.5 g.由于菇床平坦,有利于快速采摘,降低勞動力達52%(P. ostreatus)或64%(P. sajor-caju).在薄膜下面,平菇的菌絲保持健白色,健康狀態,而傳統的栽培經過一輪的采摘后,菌絲變黃.用薄膜覆蓋技術很少出現菇體不能發育成熟的現象.因此這種建立在提高栽培料組合和發酵基礎上的平菇栽培新方法值得推薦.
關鍵詞：平菇; 栽培; 菇床; 栽培料
CLC Number：S646.1+4
Foundation Item：Supported by Rural Development of Administration (RDA)
Author Resume：Oh Se Jong,male,born in 1961,researcher.Address: Div. of Applied Microbiology, National Institute of Agricultural Science and Technology, RDA 441-707 Suwon Korea.E-mail : sejongoh@rda.go.kr
Author Unit：Oh Se Jong（National Institute of Agricultural Science and Technology,RDA,441-707,Suwon Korea）
Park Jeong Sik（National Institute of Agricultural Science and Technology,RDA,441-707,Suwon Korea）
Shin Pyung Gyun（National Institute of Agricultural Science and Technology,RDA,441-707,Suwon Korea）
Yoo Young Bok（National Institute of Agricultural Science and Technology,RDA,441-707,Suwon Korea）
References：
［1］Ivanovich-Biserka B. Dealing with microbiological trouble-makers in commercial spawn production of Agaricus bisporus.Mushroom Science,1972,8: 305～314
［2］Fritsche G. Some remarks on the breeding, maintenance of strains and spawn of Agaricus bisporus and A. bitorquis. Mushroom Science,1981,11: 367～385
［3］Lemke G. Praktische Erfahrungen bei der Brutherstellung. Der Champignon,1972,126: 2～23
［4］Stoller B B. Some practical aspects of making mushroom spawn. Mushroom Science,1962, 5: 170～184
［5］Chang S T, Hays W A. The biology and cultivation of edible mushrooms. London and N Y:Academic press,1978. 219～237
［6］Paul P, John D. Shiitake growers handbook. Kendall/Hunt publishing company,1990
［7］Block S S, Tsao G ,Han C . Experiments in the cultivation of Pleurotus ostreatus.Mushroom Science,1959, 4: 309～329
［8］Chang S T,Miles P G,eds.Edible mushrooms and their cultivation. Boca Raton, Florida:CRC Press,1987.18～25
［9］Carapiet G. Phase Ⅱor cookout. Mushroom Sci, 1981,11(part 1): 311～318
［10］Gerrits J P G. Factors in bulk pasteurization and spawn-running. Mushroom Sci,1981,11(part 1): 351～365
［11］Wang H C ,Shou C H The Development of phase Ⅱcomposting for mushroom cultivation in China. Mushroom Sci,1981, 11(part 1): 319～326
［12］Oh S J, Shin P G, Weon H Y, et al.Effect of fermented sawdust on Pleurotus spawn. Mycobiology,2003,31(1): 46～49
［13］Omori S. Some discussions about the cultivation of Pleurotus ostreatus on sawdust bed. Mushroom Science,1974,: 663～665
［15］Park Y H, Go S J, Chang H C. Studies on the cultivation of Oyster Mushroom, Pleurotus ostreatus (Fr.) Quel. Using rice straw as growing substrate Ⅱ. The effect of heat treatment to the substrate. Report O R D. 1977,19(S.F.P. &M): 93～97
［16］Park Y H, Go S J,Kim D S.Studies on the cultivation of Oyster Mushroom, Pleurotus ostreatus (Fr.) Quel. Using rice straw as growing substrate Ⅰ. Experiment on the development of growing substrates. Report O R D,1975,17(S.F.P. &M): 103～107
［17］Tan K K. Cotton waste is a good substrate for cultivation of Pleurotus ostreatus, the Oyster Mushroom. Mushroom Science. 1981,11: 667～673
［18］Harman G E,Kubicek C P. Trichoderma & Gliocladium. Volume 2. London:Taylor & Francis Ltd,1998
［19］Kneebone L R, Merek E L. Brief outline of and controls for mushroom pathogens, weed mould and competitors. Mushroom Growers Assoc Bull,1959,113: 146～153
［20］Smith J F, Hayes W A. Use of autoclaved substrates in nutritional investigations on the cultivated mushroom. Mushroom Sci, 1972, 8: 355～361
［21］Kurtzman R H,Zadrazil F.Physiological and taxonomic considerations for cultivation of Pleurotus mushrooms, in tropical mushrooms. Hong Kong:The Chinese University Press,1982. 299
［14］Jandaik C L,Kapoor J N,Studies on Cultivation of Plurolus sajor-caju Mushroom Sciexce IX(Part I),1974,:667～672
華中農業大學學報
JOURNAL OF HUAZHONG AGRICULTURAL UNIVERSITY
2004 Vol.23 No.1
